Grey correlation analysis on related factors of temperature drift in magnetic modulated DCCT
-
摘要: 为进一步改善磁调制DCCT(Direct Current Current Transducer)的温度特性,将磁调制DCCT化整为零,利用灰色相关理论确定了DCCT各部分温度系数对整机的影响程度;同时,还提出了一种磁调制DCCT温度系数综合评价方法。根据磁调制DCCT的工作原理,把DCCT分为PCB(Printed Circuit Board)、线圈和取样电阻三部分,并分别测出DCCT整机、PCB、线圈和取样电阻的温度系数;然后,利用灰色相关理论对7个被测DCCT的各部分温度系数进行关联计算,获得相应的关联系数,从而确定DCCT温度特性的主要因素。根据DCCT温度特性的主、次要因素并结合工程实际,设定了概念DCCT作为参考,利用灰色相关理论计算出7个被测DCCT与参考DCCT的温度系数的灰色关联加权值,完成了被测磁调制DCCT温度性能的综合评价。最后,指出了降低DCCT整机温度敏感性的研究方向。Abstract: To further improve the temperature characteristics of magnetic modulation DCCT (Direct Current Current Transducer), the effects of various parts on the DCCT performance about temperature coefficient are found out by dividing the magnetic modulation DCCT into parts with grey correlation theory; at the same time, a comprehensive evaluation method of temperature coefficient of magnetic modulation DCCT is proposed. According to the working principle of magnetic modulation DCCT, DCCT is divided into three parts: printed circuit board (PCB), coil and sampling resistance. The temperature coefficients of them of the whole DCCT, PCB, coil and sampling resistance are measured respectively; then, temperature coefficient of each part of the 7 tested DCCT is calculated by using the grey correlation theory, and the correlation coefficients between the parts are obtained. Based on factors of the temperature characteristics and actual requirements, a concept DCCT is set as the reference. Using the grey correlation theory, the temperature comprehensive evaluation of the 7 tested magnetic modulation DCCTs is provided. The results provide a direction to reduce the temperature sensitivity of DCCT.
-
Key words:
- hard X-ray /
- current sensor /
- temperature drift /
- magnetic modulation /
- grey correlation /
- DCCT /
- temperature coefficient
-
表 1 实验结果
Table 1. Results of experiments
type of DCCT temperature coefficient/(μV·℃−1) DCCT PCB coil Rs Sinap-DCCT 400A 1# 0.6271 0.5361 0.1136 0.0206 Sinap-DCCT 200A 0.2416 0.4491 0.1685 0.0316 LEM IT 400-S 1# 0.5317 0.4744 0.3542 0.0491 LEM IT 400-S 2# 1.4765 0.8584 1.3309 0.0512 Sinap-DCCT 400A 2# 1.0717 0.8593 0.2831 0.0323 Sinap-DCCT 1000A 1# 1.9010 1.5298 0.7049 0.0242 Sinap-DCCT 1000A 2# 0.6864 1.1417 0.0652 0.0607 表 2 DCCT各部分温度系数的相关系数
Table 2. Correlation coefficients of Ct in each part of DCCT
different part TC of DCCT TC of PCB TC of coil TC of Rs TC of DCCT 1.000 000 − − − TC of PCB 0.802 208 1.000 000 − − TC of coil 0.718 670* 0.297 793 1.000 000 − TC of Rs −0.138 720** 0.031 939 0.169 575 1.000 000 *表示显著相关(P<0.05),**表示极显著(P<0.01) 表 3 DCCT温度特性及构成因素灰色关联分析标准化结果
Table 3. Standardized results of grey correlation analysis between temperature characteristics and composition factors of DCCT
type of DCCT TC of DCCT(X0) TC of PCB(X1) TC of coil(X2) TC of Rs(X3) Sinap-DCCT 400A 1# −0.525 2 −0.754 0 −0.706 2 −1.182 6 Sinap-DCCT 200A −1.185 4 −0.973 1 −0.584 1 −0.456 4 LEM IT 400-S 1# −0.688 6 −0.909 4 −0.171 7 0.700 6 LEM IT 400-S 2# 0.929 7 0.057 5 1.997 8 0.834 2 Sinap-DCCT 400A 2# 0.236 4 0.060 0 −0.329 6 −0.410 0 Sinap-DCCT 1000A 1# 1.656 8 1.748 2 0.607 4 −0.948 3 Sinap-DCCT 1000A 2# −0.423 7 0.770 9 −0.813 6 1.462 5 表 4 DCCT温度特性及构成因素灰色关联分析的Δi(k)
Table 4. Δi(k) of grey correlation analysis between temperature characteristics and components of DCCT
type of DCCT TC of PCB(X1) TC of coil(X2) TC of Rs(X3) Sinap-DCCT 400A 1# 0.228 8 0.181 0 0.657 4 Sinap-DCCT 200A 0.212 4 0.601 3 0.729 0 LEM IT 400-S 1# 0.220 8 0.516 9 1.389 2 LEM IT 400-S 2# 0.872 2 1.068 1 0.095 5 Sinap-DCCT 400A 2# 0.176 5 0.566 0 0.646 4 Sinap-DCCT 1000A 1# 0.091 4 1.049 4 2.605 1 Sinap-DCCT 1000A 2# 1.194 6 0.389 9 1.886 2 表 5 DCCT温度特性与构成因素的
${\xi _{\rm{i}}}(k)$ Table 5.
${\xi _{\rm{i}}}(k)$ between temperature characteristics and composition factors of DCCTtype of DCCT TC of PCB(X1) TC of coil(X2) TC of Rs(X3) Sinap-DCCT 400A 1# 0.910 3 0.939 6 0.711 2 Sinap-DCCT 200A 0.920 2 0.732 2 0.686 2 LEM IT 400-S 1# 0.915 1 0.766 1 0.517 9 LEM IT 400-S 2# 0.641 0 0.588 0 0.997 1 Sinap-DCCT 400A 2# 0.942 5 0.746 0 0.715 2 Sinap-DCCT 1000A 1# 1.000 0 0.592 7 0.356 7 Sinap-DCCT 1000A 2# 0.558 2 0.823 6 0.437 2 mean 0.841 0 0.741 2 0.631 6 rank 1.000 0 2.000 0 3.000 0 表 6 基于灰色关联分析的DCCT综合评价的标准化结果
Table 6. Standardized results of comprehensive evaluation of DCCT based on grey correlation analysis
type of DCCT TC of DCCT TC of PCB TC of coil TC of Rs reference 1.000 0 1.000 0 1.000 0 1.000 0 Sinap-DCCT 400A 1# 0.313 5 0.335 1 0.081 1 0.206 1 Sinap-DCCT 200A 0.120 8 0.280 7 0.120 4 0.316 1 LEM IT 400-S 1# 0.265 8 0.296 5 0.253 0 0.491 4 LEM IT 400-S 2# 0.738 3 0.536 5 0.950 6 0.511 7 Sinap-DCCT 400A 2# 0.535 9 0.537 1 0.202 2 0.323 2 Sinap-DCCT 1000A 1# 0.950 5 0.956 1 0.503 5 0.241 6 Sinap-DCCT 1000A 2# 0.343 2 0.713 5 0.046 6 0.606 9 表 7 基于灰色关联分析的DCCT综合评价的Δi(k)
Table 7. Δi(k) of DCCT’s comprehensive evaluation based on grey relational analysis
type of DCCT TC of DCCT TC of PCB TC of coil TC of Rs Sinap-DCCT 400A 1# 0.686 5 0.664 9 0.918 9 0.793 9 Sinap-DCCT 200A 0.879 2 0.719 3 0.879 6 0.683 9 LEM IT 400-S 1# 0.734 2 0.703 5 0.747 0 0.508 6 LEM IT 400-S 2# 0.261 7 0.463 5 0.049 4 0.488 3 Sinap-DCCT 400A 2# 0.464 1 0.462 9 0.797 8 0.676 8 Sinap-DCCT 1000A 1# 0.049 5 0.043 9 0.496 5 0.758 4 Sinap-DCCT 1000A 2# 0.656 8 0.286 5 0.953 4 0.393 1 表 8 7个被测DCCT与参考DCCT的
${\xi _{\rm{i}}}(k)$ Table 8.
${\xi _{\rm{i}}}(k)$ between 7 tested DCCTs and reference DCCTtype of DCCT TC of DCCT TC of PCB TC of coil TC of Rs Sinap-DCCT 400A 1# 0.447 6 0.456 0 0.373 0 0.409 7 Sinap-DCCT 200A 0.383 9 0.435 3 0.383 8 0.448 6 LEM IT 400-S 1# 0.429 9 0.441 1 0.425 4 0.528 4 LEM IT 400-S 2# 0.705 0 0.553 7 0.989 6 0.539 5 Sinap-DCCT 400A 2# 0.553 3 0.554 0 0.408 5 0.451 3 Sinap-DCCT 1000A 1# 0.989 3 1.000 0 0.534 9 0.421 5 Sinap-DCCT 1000A 2# 0.459 3 0.682 1 0.364 0 0.598 5 表 9 7个被测DCCT与参考DCCT的关联度及排序
Table 9. Correlation and rank between 7 tested DCCTs and reference DCCT
type of DCCT equal correlation weighted correlation coefficient rank coefficient rank Sinap-DCCT 400A 1# 0.421 6 6 0.431 4 6 Sinap-DCCT 200A 0.412 9 7 0.405 8 7 LEM IT 400-S 1# 0.456 2 5 0.442 2 5 LEM IT 400-S 2# 0.696 9 2 0.700 0 2 Sinap-DCCT 400A 2# 0.491 8 4 0.514 4 4 Sinap-DCCT 1000A 1# 0.736 4 1 0.844 9 1 Sinap-DCCT 1000A 2# 0.526 0 3 0.521 0 3 -
[1] 焦毅, 翟纪元, 陆辉华, 等. 基于超导直线加速器的XFEL初步方案[J]. 强激光与粒子束, 2015, 27:055101. (Jiao Yi, Zhai Jiyuan, Lu Huihua, et al. Primary scheme of superconducting linac-driven XFEL in China[J]. High Power Laser and Particle Beams, 2015, 27: 055101 doi: 10.11884/HPLPB201527.055101 [2] 赵振堂, 冯超. X射线自由电子激光[J]. 物理, 2018, 47(8):481-490. (Zhao Zhentang, Feng Chao. X-ray free electron lasers[J]. Physics, 2018, 47(8): 481-490 doi: 10.7693/wl20180801 [3] 赵振堂, 王东, 殷立新, 等. 上海软X射线自由电子激光装置[J]. 中国激光, 2019, 46:0100004. (Zhao Zhentang, Wang Dong, Yin Lixin, et al. Shanghai soft X-ray free-electron laser facility[J]. Chinese Journal of Lasers, 2019, 46: 0100004 doi: 10.3788/CJL201946.0100004 [4] 王东兴, 李瑞, 郭春龙, 等. 质子加速器注入、引出磁铁电源的纹波抑制[J]. 原子能科学技术, 2019, 53(9):1 577-1 582. (Wang Dongxing, Li Rui, Guo Chunlong, et al. Ripple rejection of power supply in injection and extraction magnet in proton accelerator[J]. Atomic Energy Science and Technology, 2019, 53(9): 1 577-1 582 [5] 王东兴, 朱燕燕, 李瑞, 等. 基于开环增益的DCCT线性误差测量评估方法[J]. 西北大学学报: 自然科学版, 2018, 48(3):343-348. (Wang Dongxing, Zhu Yanyan, Li Rui, et al. A linearity error measurement method based on open-loop gain in DCCT[J]. Journal of Northwest University: Natural Science Edition, 2018, 48(3): 343-348 [6] 王东兴, 朱燕燕, 李瑞, 等. 磁调制零磁通电流传感器状态监测方法[J]. 西安电子科技大学学报: 自然科学版, 2018, 45(3):169-174. (Wang Dongxing, Zhu Yanyan, Li Rui, et al. States monitoring method of zero-flux current sensor based on magnetic modulation[J]. Journal of Xidian University, 2018, 45(3): 169-174 [7] 韩超, 龙锋利, 程健, 等. 直流电流传感器高精度校准系统设计[J]. 原子能科学技术, 2020, 54(1):166-171. (Han Chao, Long Fengli, Cheng Jian, et al. Design of high-precision calibration system for direct current-current transformer[J]. Atomic Energy Science and Technology, 2020, 54(1): 166-171 doi: 10.7538/yzk.2019.youxian.0020 [8] 李敏, 聂勇敢, 李生鹏, 等. 基于EPICS的CSRe束流诊断控制系统升级[J]. 强激光与粒子束, 2019, 31:125103. (Li Min, Nie Yonggan, Li Shengpeng, et al. Upgrade of CSRe beam diagnostic control system based on EPICS[J]. High Power Laser and Particle Beams, 2019, 31: 125103 doi: 10.11884/HPLPB201931.190144 [9] 张子忠. 基于NB-IoT 的分布式光伏电站漏电监测系统[D]. 保定: 华北电力大学, 2019: 3-5.Zhang Zizhong. Leakage monitoring system of distributed photovoltaic power station based on NB-IoT[D]. Baoding: North China Electric Power University, 2019: 3-5. [10] 王农. 精密测量直流大电流的自激振荡磁通门法研究[D]. 哈尔滨: 哈尔滨工业大学, 2016: 64-66.Wang Nong. Self-oscillating fluxgate technology for precision measurement of DC high current[D]. Harbin: Harbin Institute of Technology, 2016: 64-66). [11] 邵霞. 电流型电子式电压互感器关键技术及其应用研究[D]. 长沙: 湖南大学, 2013: 15-16.Shao Xia. Research on key techniques of current-based electronic voltage transformer and their application[D]. Changsha: Hunan University, 2013: 15-16. [12] 万丽. 航天用高精度霍尔电流传感器开发技术研究[D]. 西安: 西安电子科技大学, 2011: 5-24.Wan Li. Technology development of an astronautic high precision Hall current sensor[D]. Xi’an: Xidian University, 2011: 5-24. [13] 国旗, 傅鹏, 蒋力. 霍尔传感器温度漂移补偿电路设计[J]. 强激光与粒子束, 2017, 29:046003. (Guo Qi, Fu Peng, Jiang Li. Design of temperature compensation for Hall sensor[J]. High Power Laser and Particle Beams, 2017, 29: 046003 doi: 10.11884/HPLPB201729.160466 [14] 戚继飞, 阳桂蓉, 罗志强. 相位差磁调制直流漏电流传感器误差分析[J]. 自动化与仪器仪表, 2018, 227(9):149-152. (Qi Jifei, Yang Guirong, Luo Zhiqiang. Error analysis of phase difference magnetic modulation DC leakage current sensor[J]. Automation and Instrumentation, 2018, 227(9): 149-152 [15] 王东兴, 朱燕燕, 李瑞, 等. 磁调制DCCT调制噪声及测量方法研究[J/OL]. 原子能科学技术, 2020.Wang Dongxing, Zhu Yanyan, Li Rui, et al. Study on modulation noise and its measurement method of DCCT with magnetic modulation[J/OL]. Atomic Energy Science and Technology, 2020 http://kns.cnki.net/kcms/detail/11.2044.TL.20200622.0844.002.html. [16] Maniktala S. Switching power supplies A to Z[M]. Burlington: Newnes, 2006: 15-21. [17] 李雪梅. 灰色关联分析与 GM(1,1)模型优化的研究与应用[D]. 南京: 南京航空航天大学, 2011: 1-2.Li Xuemei. Research on Grey correlation analysis, optimization of GM(1,1) Model and Their Applications[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2011: 1-2