基于脉宽脉幅混合调制技术的功耗检测电路

邢胜博; 马修泉; 王长久; 马新敏

doi:10.11884/HPLPB202335.230152

基于脉宽脉幅混合调制技术的功耗检测电路

doi: 10.11884/HPLPB202335.230152

1.
华中科技大学机械科学与工程学院，武汉 430074
2.
华中科技大学光学与电子信息学院，武汉 430074
3.
上海机电工程研究所，上海 201109

基金项目: 广东省基础与应用基础重大项目(2019B030302003)

详细信息

作者简介:
邢胜博，xingshengb@163.com

中图分类号: TM933
计量
- 文章访问数: 205
- HTML全文浏览量: 56
- PDF下载量: 54
- 被引次数: 0
出版历程
- 收稿日期: 2023-05-29
- 修回日期: 2023-11-07
- 录用日期: 2023-10-20
- 网络出版日期: 2023-11-18
- 刊出日期: 2023-12-15

Power consumption detection circuit based on pulse width-pulse amplitude hybrid modulation strategy

1.
School of Mechanical Science and Engineering, Huazhong University of Science and Technology, Wuhan 430074, China
2.
School of Optical and Electronic Information, Huazhong University of Science and Technology, Wuhan 430074, China
3.
Shanghai Electro-Mechanical Engineering Institute, Shanghai 201109, China

摘要

摘要: 线性电源因其干扰小、动态响应速度快等优点被广泛用作半导体激光器驱动电源。针对线性电源中调整管易因功耗过大发生故障的问题，提出了一种脉宽脉幅混合调制方法，利用调整管漏源电压和漏极电流调制生成高频方波，通过平均值电路计算方波平均值，并基于此方法设计了一种调整管功耗检测电路。搭建实验平台对电路进行测试，结果表明，电路检测精度高、硬件成本低、响应速度快，最大检测误差为−2.64%，线性拟合度为0.9987，可广泛用于调整管的功耗检测以及安全区保护。
- 调整管 /
- 功耗检测 /
- 混合调制 /
- 线性电源 /
- 半导体激光器
Abstract: Linear power supply is widely used as the driving power of semiconductor laser because of its advantages such as low interference and fast dynamic response. To solve the problem that the regulating tube fails due to excessive power consumption, this paper proposes a hybrid pulse width-pulse amplitude modulation strategy, which uses the drain-source voltage and drain-current of the regulating tube to modulate high frequency square wave, and calculate the mean value of square wave, based on which the regulating tube power consumption detection circuit is designed. An experimental platform is built to test the circuit, and the results show that the circuit has the advantages of excellent detection accuracy, low hardware cost and fast response. The circuit has a maximum relative error of $- 2.64{\text{%}} $ and a linearity fit of $ 0.9987 $. It can be widely used for power consumption measurement and safety zone protection of regulating tube.
- regulating tube /
- power consumption detection /
- hybrid modulation /
- linear power supply /
- semiconductor laser

HTML全文

图 1 串联反馈式线性电流源

Figure 1. Series feedback linear current source

下载: 全尺寸图片幻灯片

图 2 高频受调方波

Figure 2. High frequency modulated square wave

下载: 全尺寸图片幻灯片

图 3 基于PWAM技术的功耗检测电路原理框图

Figure 3. Power consumption detection circuit functional block diagram based on PWAM technology

下载: 全尺寸图片幻灯片

图 4 基于PWAM技术的功耗检测电路原理图

Figure 4. Power consumption detection circuit schematic diagram based on PWAM technology

下载: 全尺寸图片幻灯片

图 5 基于PWAM技术的功耗检测验证电路

Figure 5. Power detection of verification circuit based on PWAM technology

下载: 全尺寸图片幻灯片

图 6 不同工况下调制波形

Figure 6. Modulation waveform under different working conditions

下载: 全尺寸图片幻灯片

图 7 实际功耗和检测值的线性拟合

Figure 7. Linear fitting of actual values and detected values

下载: 全尺寸图片幻灯片

表 1 不同频率下功耗检测误差分析

Table 1. Error analysis of power consumption detection at different frequencies

frequency ${f_{\mathrm{s}}}$/kHz	maximum relative error ${\delta _{\max }}$/%	mean square error (MSE)	linear fit ${R^2}$
75	−2.78	0.314	0.9965
100	−2.64	0.237	0.9987
125	−3.04	0.403	0.9788
150	−3.26	0.491	0.9617
175	−4.43	0.515	0.9478

下载: 导出CSV

表 2 采样频率为100 kHz时对应的实验数据

Table 2. Experimental data corresponding to a sampling frequency of 100 kHz

drain current $ \text{ }{i}_{{\mathrm{d}}} $/A	drain source voltage $ \text{ }{v}_{{\mathrm{ds}}} $/V	true value ${P_{\mathrm{r}}}$/W	analog output ${V_{\mathrm{a}}}$/V	detected value P/W	relative error $\delta $/%
1	18.98	18.98	0.298	18.48	−2.64
2	14.96	29.92	0.476	29.44	−1.60
3	12.28	36.84	0.598	37.02	0.48
4	11.02	44.08	0.717	44.41	0.76
5	9.84	49.20	0.804	49.78	1.19
6	9.02	54.12	0.885	54.77	1.20
7	8.26	57.82	0.939	58.11	0.50
8	7.62	60.96	0.987	61.13	0.28
9	7.10	63.90	1.027	63.58	−0.50
10	6.54	65.40	1.043	64.57	−1.27
11	6.16	67.76	1.091	67.52	−0.35
12	5.68	68.16	1.084	67.11	−1.54
13	5.18	67.34	1.078	66.77	−0.85
14	4.72	66.08	1.069	66.18	0.15
15	4.36	65.40	1.070	66.22	1.26
16	4.06	64.96	1.045	64.67	−0.44
17	3.64	61.88	0.997	61.70	−0.29
18	3.26	58.68	0.943	58.36	−0.55
19	2.84	53.96	0.869	53.81	−0.28
20	2.34	46.80	0.753	46.59	−0.44

下载: 导出CSV

参考文献(13)

[1]	余俊宏, 郭林辉, 王昭, 等. 200 W级高亮度半导体激光器光纤耦合模块[J]. 强激光与粒子束, 2014, 26:111001 doi: 10.3788/HPLPB20142611.111001 Yu Junhong, Guo Linhui, Wang Zhao, et al. High brightness fiber coupled diode laser module with 200 W class output power[J]. High Power Laser and Particle Beams, 2014, 26: 111001 doi: 10.3788/HPLPB20142611.111001
[2]	沈晓红, 曾盈莹, 毛琳, 等. 双波长自锁模半导体薄片激光器[J]. 物理学报, 2022, 71:204202 doi: 10.7498/aps.71.20220483 Shen Xiaohong, Zeng Yingying, Mao Lin, et al. Dual-wavelength self-mode-locked semiconductor disk laser[J]. Acta Physica Sinica, 2022, 71: 204202 doi: 10.7498/aps.71.20220483
[3]	田亚玲, 李创社, 张朝阳. 高精度和高稳定性半导体激光器恒流驱动电源[J]. 西安交通大学学报, 2019, 53(3):1-5 Tian Yaling, Li Chuangshe, Zhang Zhaoyang. High-accuracy and high-stability constant current power for semiconductor lasers[J]. Journal of Xi'an Jiaotong University, 2019, 53(3): 1-5
[4]	张龙, 陈建生, 高静, 等. 大功率半导体激光器驱动电源及温控系统设计[J]. 红外与激光工程, 2018, 47:1005003 doi: 10.3788/IRLA201847.1005003 Zhang Long, Chen Jiansheng, Gao Jing, et al. Design of driving power and temperature control system for high power semiconductor laser[J]. Infrared and Laser Engineering, 2018, 47: 1005003 doi: 10.3788/IRLA201847.1005003
[5]	Zhu Xueli, Zhang Donglai, Gao Wei. Online noninvasive technique for condition monitoring of capacitor in linear power supplies[J]. IEEE Transactions on Power Electronics, 2021, 36(8): 8761-8773. doi: 10.1109/TPEL.2021.3057593
[6]	熊刚, 王伟平. 一种开关线性复合电源及控制策略[J]. 电子测试, 2021(19):18-20,17 Xiong Gang, Wang Weiping. A switch linearity hybrid power supply and its control strategy[J]. Electronic Test, 2021(19): 18-20,17
[7]	Ebadi M, Abbasi N, Maghsoudi H. A fast and cost-effective short circuit protection scheme for low-power converters for small-scale photovoltaic application[J]. Circuit World, 2022, 48(3): 366-376. doi: 10.1108/CW-11-2021-0281
[8]	许迪迪, 张小玲, 齐浩淳, 等. 功率MOSFET器件安全工作区的研究[J]. 电力电子技术, 2018, 52(8):70-72 Xu Didi, Zhang Xiaoling, Qi Haochun, et al. Research on safe operating area of power MOSFET devices[J]. Power Electronics, 2018, 52(8): 70-72
[9]	饶俊峰, 曾彤, 李孜, 等. 固态Marx发生器的过流保护研究[J]. 强激光与粒子束, 2019, 31:125001 doi: 10.11884/HPLPB201931.190138 Rao Junfeng, Zeng Tong, Li Zi, et al. Study on over-current protection of solid-state Marx generators[J]. High Power Laser and Particle Beams, 2019, 31: 125001 doi: 10.11884/HPLPB201931.190138
[10]	刘平, 刘叶春, 苗轶如. 基于瞬时功耗检测的SiC MOSFET短路保护策略[J]. 固体电子学研究与进展, 2022, 42(4):263-268,280 Liu Ping, Liu Yechun, Miao Yiru. Short circuit protection strategy of SiC MOSFET based on instantaneous power detection[J]. Research & Progress of SSE, 2022, 42(4): 263-268,280
[11]	李杰, 陈庆奎. 基于蓝牙4.0的GPU集群功耗测量系统设计[J]. 电子检测与仪器学报, 2014, 28(3):314-319 Li Jie, Chen Qingkui. Design of GPU cluster power consumption measurement system based on Bluetooth 4.0[J]. Journal of Electronic Measurement and Instrumentation, 2014, 28(3): 314-319
[12]	文阳. SiC MOSFET模块驱动保护电路研究[D]. 西安: 西安理工大学, 2020: 69-79 Wen Yang. Study on SiC MOSFET module drive and protection circuit[D]. Xi’an: Xi’an University of Technology, 2020: 69-79
[13]	刘增水, 陈瑜迪. 二阶低通滤波器仿真分析及其应用[J]. 电子设计工程, 2019, 27(16):180-184 Liu Zengshui, Chen Yudi. Simulation analysis and application of second-order low-pass filter[J]. Electronic Design Engineering, 2019, 27(16): 180-184