LLC high voltage capacitor charging power supply design with variable bus voltage

Zeng Yuxuan; Patrick J Palanas; Yu Kexun; Xie Xianfei

doi:10.11884/HPLPB202436.230151

Volume 36 Issue 2

Jan. 2024

Turn off MathJax

Article Contents

Article Navigation > High Power Laser and Particle Beams > 2024 > 36(2): 025013

Zeng Yuxuan, Patrick J Palanas, Yu Kexun, et al. LLC high voltage capacitor charging power supply design with variable bus voltage[J]. High Power Laser and Particle Beams, 2024, 36: 025013. doi: 10.11884/HPLPB202436.230151

Citation:

Zeng Yuxuan, Patrick J Palanas, Yu Kexun, et al. LLC high voltage capacitor charging power supply design with variable bus voltage[J]. High Power Laser and Particle Beams, 2024, 36: 025013. doi: 10.11884/HPLPB202436.230151

Citation:

PDF( 4994 KB)

LLC high voltage capacitor charging power supply design with variable bus voltage

doi: 10.11884/HPLPB202436.230151

School of Electrical and Electronic Engineering, Huazhong University of Science and Technology, Wuhan 430074, China

Received Date: 2023-05-29
Accepted Date: 2023-10-09
Rev Recd Date: 2023-09-20

Available Online: 2023-12-21

Publish Date: 2024-01-12

Abstract

Abstract

This paper proposes, a two-stage variable bus voltage high-voltage capacitor charging power supply technical scheme which adds a one-stage totem-pole bridgeless power factor correction (PFC) circuit on the basis of the half-bridge LLC resonant circuit, and solves the problem of the decline in charging efficiency caused by the excessive operating frequency variation range of the traditional LLC resonant power supply when the output voltage is higher. Since the totem-pole circuit itself has the function of power factor correction, the power supply design also has the advantage of being able to draw power directly from the grid without affecting the power quality of the grid. This paper first introduces the circuit topology and working principle of the two parts of this power supply design, and analyzes the output characteristics of the power supply under capacitive load by the equivalent resistance method. For the pre-stage totem-pole circuit, a double-loop controller is designed to realize the control of bus voltage and power factors, and a constant current controller with proportional-integral (PI) plus low-pass filtering control is proposed for the post-stage LLC circuit to reduce the adverse effects of high-frequency noise. Finally, through model construction and simulation analysis, the charging characteristics of high-voltage capacitor charging power supply at 3000V/1 A are studied, and the feasibility of the technical scheme, design and control strategy of the power supply is verified.

FullText(HTML)

References(15)

References

[1]	冯传均, 何泱, 戴文峰, 等. 串联谐振高压电容充电电源设计及分析[J]. 强激光与粒子束, 2019, 31:055002 doi: 10.11884/HPLPB201931.180355 Feng Chuanjun, He Yang, Dai Wenfeng, et al. Design and analysis of series resonant high voltage capacitor charging power supply[J]. High Power Laser and Particle Beams, 2019, 31: 055002 doi: 10.11884/HPLPB201931.180355
[2]	Wang Yuchen, Yang Yahong, Wang Lei, et al. Optimal design of high-efficiency series resonant capacitor charging power supply[C]//2022 IEEE 6th Information Technology and Mechatronics Engineering Conference (ITOEC). 2022: 7-10.
[3]	钱黎涛, 王德玉, 于建萍, 等. 基于LCC-LC谐振变换器的高压储能电源研究[J]. 强激光与粒子束, 2020, 32:075004 doi: 10.11884/HPLPB202032.200074 Qian Litao, Wang Deyu, Yu Jianping, et al. Research on high voltage energy storage power supply of pulse plasma thruster based on LCC-LC resonant converter[J]. High Power Laser and Particle Beams, 2020, 32: 075004 doi: 10.11884/HPLPB202032.200074
[4]	曹沛, 徐向宇, 马英麒. 基于LC全桥串联谐振的脉冲功率电源设计[J]. 电力电子技术, 2017, 51(5):68-70,74 Cao Pei, Xu Xiangyu, Ma Yingqi. Design of pulsed power supply based on LC full-bridge series resonant converter[J]. Power Electronics, 2017, 51(5): 68-70,74
[5]	黄毛毛, 李瑞, 李德明, 等. LLC谐振恒流恒压高压充电电源技术研究[J]. 原子能科学技术, 2019, 53(9):1588-1594 Huang Maomao, Li Rui, Li Deming, et al. Research on LLC resonant constant current constant voltage high voltage charging power supply technology[J]. Atomic Energy Science and Technology, 2019, 53(9): 1588-1594
[6]	刘松林, 潘健, 陈庆东, 等. 宽输出LLC谐振变换器的定频PWM控制策略[J]. 电源学报, 2023, 21(1):26-34 Liu Songlin, Pan Jian, Chen Qingdong, et al. Fixed-frequency PWM control strategy of LLC resonant converter for wide output range[J]. Journal of Power Supply, 2023, 21(1): 26-34
[7]	张政权, 刘庆想, 向欣, 等. 高频整流谐振变换电源[J]. 强激光与粒子束, 2010, 22(4):721-724 doi: 10.3788/HPLPB20102204.0721 Zhang Zhengquan, Liu Qingxiang, Xiang Xin, et al. High-frequency rectifying commutated converter[J]. High Power Laser and Particle Beams, 2010, 22(4): 721-724 doi: 10.3788/HPLPB20102204.0721
[8]	钱城晖, 钱挺. 辅助半桥调节的定频LLC谐振功率变换器[J]. 电工技术学报, 2019, 34(7):1459-1467 Qian Chenghui, Qian Ting. A fixed-frequency LLC resonant converter adjusted by auxiliary half-bridge[J]. Transactions of China Electrotechnical Society, 2019, 34(7): 1459-1467
[9]	经雯荔, 管乐诗, 王懿杰, 等. 高频AC/DC变换器优化控制策略研究[J]. 电源学报, 2020, 18(5):60-71 Jing Wenli, Guan Yueshi, Wang Yijie, et al. Research on optimal control strategy for high-frequency AC/DC converter[J]. Journal of Power Supply, 2020, 18(5): 60-71
[10]	Su Bin, Lu Zhengyu. An interleaved totem-pole boost bridgeless rectifier with reduced reverse-recovery problems for power factor correction[J]. IEEE Transactions on Power Electronics, 2010, 25(6): 1406-1415. doi: 10.1109/TPEL.2010.2040633
[11]	Su Bin, Zhang Junming, Lu Zhengyu. Totem-pole boost bridgeless PFC rectifier with simple zero-current detection and full-range ZVS operating at the boundary of DCM/CCM[J]. IEEE Transactions on Power Electronics, 2011, 26(2): 427-435. doi: 10.1109/TPEL.2010.2059046
[12]	Huang Long, Yao Wenxi, Lu Zhengyu. Interleaved totem-pole bridgeless PFC rectifier with ZVS and low input current ripple[C]//2015 IEEE Energy Conversion Congress and Exposition (ECCE). 2015: 166-171.
[13]	章治国, 李世锋, 李鑫, 等. 一种可工作于CCM模态的高效图腾柱无桥PFC变换器[J]. 中国电机工程学报, 2022, 42(5):1957-1967 Zhang Zhiguo, Li Shifeng, Li Xin, et al. A high efficiency totem-pole bridgeless PFC converter in CCM mode[J]. Proceedings of the CSEE, 2022, 42(5): 1957-1967
[14]	孙战, 王懿杰. 基于图腾柱无桥PFC的软开关控制变换研究[J]. 电力工程技术, 2022, 41(1):70-76 Sun Zhan, Wang Yijie. Soft switch control transformation based on totem pole bridgeless PFC[J]. Jiangsu Electrical Engineering, 2022, 41(1): 70-76
[15]	陈申, 吕征宇, 姚玮. LLC谐振型软开关直流变压器的研究与实现[J]. 电工技术学报, 2012, 27(10):163-169 Chen Shen, Lv Zhengyu, Yao Wei. Research and verification on LLC resonant soft switching DC-DC transformer[J]. Transactions of China Electrotechnical Society, 2012, 27(10): 163-169