Estimation of low probability pre-fire of multi-gap gas switch for linear transformer driver
-
摘要: 开关触发前发生的低概率自击穿故障，是制约直线变压器驱动源（LTD）技术发展和工程应用的主要因素。针对多间隙气体开关的自放电概率展开研究，设计了简化结构的气体开关来测量更高气压下的自击穿电压；推导了考虑间隙分压不均的开关自击穿电压累积分布函数，计算LTD工作气压下的多间隙开关自击穿电压分布特性并进行实验验证；通过超越阈值方法对低工作系数下的小概率自放电事件进行威布尔分布拟合，得到自放电概率估计值；对气体开关开展了万发次考核实验，得到自放电概率测量值。结果表明：开关的自击穿电压分散性随着气压升高而增加，测量低气压下的自击穿电压无法外推得到实际工作高气压条件下的自放电概率；开关工作系数为65%和60%时，气体开关的自放电概率估计值为
$1.44 \times {10^{ - 4}}$ 和$3.01 \times {10^{ - 5}}$ ，与开关万发次考核的实验结果相近，验证了估计方法的可行性。Abstract: The pre-fire of gas switches is the unexpected breakdown at triggered mode, which is the main factor restricting the development and engineering application of linear transformer driver (LTD). In this paper, the dispersion of breakdown voltage as well as pre-fire rate of multi-gap gas switches under typical working pressures of LTD was investigated and reported. A simplified gas switch was designed to measure self-breakdown voltage at higher gas pressures, and the cumulative distribution function of self-breakdown voltage considering uneven gap voltage distribution was derived. The self-breakdown voltage distribution characteristics of multi-gap switches under LTD working pressure were calculated and experimentally verified. The estimated pre-fire rate was obtained by using peak-over-threshold method to fit the Weibull distribution of small probability pre-fire events under low working coefficients. The measured pre-fire rate was obtained by a 10 000 triggering test. The results show that the dispersion of the self-breakdown voltage of the switch increased with air pressure. Measuring the self-breakdown voltage at low air pressure can not extrapolate the pre-fire rate at high pressure under actual working conditions. When the working coefficients of the gas switch were 65% and 60%, the estimated pre-fire rates were$1.44 \times {10^{ - 4}}$ and$3.01 \times {10^{ - 5}}$ , which were close to the experimental results of the 10 000 triggering test, verifying the feasibility of the estimation method.-
Key words:
- gas switch /
- linear transformer driver /
- pre-fire rate /
- Weibull distribution
-
图 1 四间隙环形电极气体开关剖面图
Figure 1. Cutaway view of the four-gap ring electrode gas switch
1-electrical connector; 2-high-voltage electrodes; 3-insulation shell; 4-intermediate electrode; 5-trigger pin; 6-insulated fastener; 7-trigger electrode
图 2 两间隙环形电极气体开关剖面图
Figure 2. Cutaway view of the two-gap ring electrode gas switch
1-electrical connector; 2-high-voltage electrodes; 3-insulation shell; 4-trigger pin; 5-insulated fastener; 6-trigger electrode
图 3 两间隙开关和四间隙开关间隙电场仿真计算结果
Figure 3. Simulation results of gap electric field between two-gap gas switch and four-gap gas switch
图 6 两间隙开关和四间隙开关的自击穿电压
Figure 6. Self-breakdown voltage of two-gap gas switch and four-gap gas switch
图 7 四间隙开关自击穿电压的计算值与测量值
Figure 7. Calculated and measured results of self-breakdown voltage for the four-gap switch
图 8 0.54 MPa气压下两间隙开关的自击穿电压
Figure 8. Self-breakdown voltage of the two-gap gas switch at a pressure of 0.54 MPa
图 10 基于POT法的小概率自放电事件的威布尔分布拟合
Figure 10. Weibull distribution fitting of small probability pre-fire events based on POT method
图 11 不同工作系数下的开关自放电概率计算结果
Figure 11. Calculation results of switch pre-fire rate under different working coefficients
-
[1] Stygar W A, Cuneo M E, Headley D I, et al. Architecture of petawatt-class z-pinch accelerators[J]. Physical Review Accelerators and Beams, 2007, 10: 030401. doi: 10.1103/PhysRevSTAB.10.030401 [2] 孙凤举, 邱爱慈, 魏浩, 等. 快Z箍缩百太瓦级脉冲驱动源概念设计的发展[J]. 现代应用物理, 2017, 8:020102 doi: 10.12061/j.issn.2095-6223.2017.020102Sun Fengju, Qiu Aici, Wei Hao, et al. Development of conceptual design on fast Z-pinch pulsed power driver with hundreds of terawatt[J]. Modern Applied Physics, 2017, 8: 020102 doi: 10.12061/j.issn.2095-6223.2017.020102 [3] Kim A A, Mazarakis M G. The story of the LTD development[J]. IEEE Transactions on Plasma Science, 2020, 48(4): 749-756. doi: 10.1109/TPS.2019.2954210 [4] Douglass J D, Hutsel B T, Leckbee J J, et al. 100 GW linear transformer driver cavity: design, simulations, and performance[J]. Physical Review Accelerators and Beams, 2018, 21: 120401. doi: 10.1103/PhysRevAccelBeams.21.120401 [5] 丛培天, 邱爱慈. 快脉冲直线变压器气体开关技术[J]. 强激光与粒子束, 2012, 24(6):1263-1268 doi: 10.3788/HPLPB20122406.1263Cong Peitian, Qiu Aici. Review on gas switches developed for fast linear transformer driver[J]. High Power Laser and Particle Beams, 2012, 24(6): 1263-1268 doi: 10.3788/HPLPB20122406.1263 [6] 黄涛. 气体开关串级间隙多通道放电特性与调控技术研究[D]. 西安: 西北核技术研究所, 2000Huang Tao. Study on multi-channel discharge characteristics and regulation technology of serial-connected gap in gas switch[D]. Xi’an: Northwest Institute of Nuclear Technology, 2000 [7] Woodworth J R, Alexander J A, Gruner F R, et al. Low-inductance gas switches for linear transformer drivers[J]. Physical Review Accelerators and Beams, 2009, 12: 060401. doi: 10.1103/PhysRevSTAB.12.060401 [8] Woodworth J R, Stygar W A, Bennett L F, et al. New low inductance gas switches for linear transformer drivers[J]. Physical Review Accelerators and Beams, 2010, 13: 080401. doi: 10.1103/PhysRevSTAB.13.080401 [9] 孙铁平, 丛培天, 罗维熙. FLTD系统放电开关自击穿性能优化[J]. 强激光与粒子束, 2016, 28:075005 doi: 10.11884/HPLPB201628.075005Sun Tieping, Cong Peitian, Luo Weixi. Improvement of self-breakdown characteristic of multi-gap switch used for fast linear transformer driver[J]. High Power Laser and Particle Beams, 2016, 28: 075005 doi: 10.11884/HPLPB201628.075005 [10] Li Xiaoang, Liu Xuandong, Zeng Fanhui, et al. Ejection of electrode molten droplet and its effect on the degradation of insulator in gas spark switches[J]. IEEE Transactions on Plasma Science, 2015, 43(4): 1049-1053. doi: 10.1109/TPS.2015.2408607 [11] 钟伟. 金属微粒引发气体火花开关击穿过程建模仿真及实验研究[D]. 西安: 西安交通大学, 2021Zhong Wei. Numerical and experimental study on breakdown in gas spark gap triggered by metallic micro particles[D]. Xi’an: Xi’an Jiaotong University, 2021 [12] Li Xiaoang, Liu Xuandong, Gou Xuanqi, et al. Degradation of performance due to electrode erosion in field distortion gas switch in long-term repetitive operation[J]. IEEE Transactions on Plasma Science, 2014, 42(10): 3064-3069. doi: 10.1109/TPS.2014.2313636 [13] 罗维熙. 直流气体开关自放电特性计算方法研究[D]. 西安: 西北核技术研究所, 2019Luo Weixi. Calculation method of self-breakdown voltage distribution in DC gas switches[D]. Xi’an: Northwest Institute of Nuclear Technology, 2019 [14] 刘轩东. 气体开关击穿特性及其对FLTD输出影响的研究[D]. 西安: 西安交通大学, 2010Liu Xuandong. Breakdown characteristics of gas switch and its influence on the output parameters of fast linear transformer driver[D]. Xi’an: Xi’an Jiaotong University, 2010 [15] Li Xiaoang, Pei Zhehao, Ma Chaoqun, et al. Prefire properties of high pressure gas spark switches for fast linear transformer drivers[J]. IEEE Transactions on Plasma Science, 2018, 46(12): 4099-4108. doi: 10.1109/TPS.2018.2864121 [16] 降宏瑜, 姜晓峰, 王志国, 等. LTD多间隙气体开关电场优化及自放率实验研究[J]. 现代应用物理, 2022, 13: 040410-1-040410-9, 040412-7Jiang Hongyu, Jiang Xiaofeng, Wang Zhiguo, et al. Electric field optimization and pre-fire rate of LTD multi-gap gas switch[J]. Modern Applied Physics, 2022, 13: 040410-1-040410-9, 040412-7 [17] 赖贵友, 杨兰均, 郭良福, 等. 大库仑两电极气体开关静态特性[J]. 强激光与粒子束, 2009, 21(1):43-46Lai Guiyou, Yang Lanjun, Guo Liangfu, et al. Static characteristic research of high-Coulomb two electrode spark gap switch[J]. High Power Laser and Particle Beams, 2009, 21(1): 43-46 [18] 丛培天, 邱爱慈, 孙铁平. 气体开关自击穿概率的分析方法比较[J]. 强激光与粒子束, 2013, 25(7):1831-1834 doi: 10.3788/HPLPB20132507.1831Cong Peitian, Qiu Aici, Sun Tieping. Comparison of Gaussian and Weibull models used for gas switch self-breakdown probability analysis[J]. High Power Laser and Particle Beams, 2013, 25(7): 1831-1834 doi: 10.3788/HPLPB20132507.1831 [19] Wu Jiawei, Han Ruoyu, Ding Weidong, et al. Experimental study of self-breakdown voltage statistics in Cu-W electrode spark gap switches[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2017, 24(4): 2056-2065. doi: 10.1109/TDEI.2017.006266 [20] 王虎, 危瑾, 常家森, 等. 场畸变气体开关寿命预测[J]. 中国电机工程学报, 2011, 31(19):153-159Wang Hu, Wei Jin, Chang Jiasen, et al. Lifetime prediction of field-distortion gas switch[J]. Proceedings of the CSEE, 2011, 31(19): 153-159 [21] Jiang Hongyu, Sun Fengju, Cong Peitian, et al. Optimization of self-breakdown and triggering characteristics on multigap gas switch by mounting resistors and capacitors in parallel with switch gaps[J]. IEEE Transactions on Plasma Science, 2019, 47(6): 2922-2928. doi: 10.1109/TPS.2019.2911563 [22] Millar R B. Maximum likelihood estimation and inference: with examples in R, SAS and ADMB[M]. New York: John Wiley & Sons, 2011. -
下载:
点击查看大图
计量
- 文章访问数: 46
- HTML全文浏览量: 28
- PDF下载量: 5
- 被引次数: 0
