Optimization desigh of new all-solid-state modular multilevel special high-voltage power supply

Li Yushan; Qian Weigang; Teng Jiaxun; Sun Xiaofeng

doi:10.11884/HPLPB202436.230322

Volume 36 Issue 2

Jan. 2024

Turn off MathJax

Article Contents

Article Navigation > High Power Laser and Particle Beams > 2024 > 36(2): 025007

Li Yushan, Qian Weigang, Teng Jiaxun, et al. Optimization desigh of new all-solid-state modular multilevel special high-voltage power supply[J]. High Power Laser and Particle Beams, 2024, 36: 025007. doi: 10.11884/HPLPB202436.230322

Citation:

Li Yushan, Qian Weigang, Teng Jiaxun, et al. Optimization desigh of new all-solid-state modular multilevel special high-voltage power supply[J]. High Power Laser and Particle Beams, 2024, 36: 025007. doi: 10.11884/HPLPB202436.230322

Citation:

PDF( 6500 KB)

Optimization desigh of new all-solid-state modular multilevel special high-voltage power supply

doi: 10.11884/HPLPB202436.230322

Li Yushan^1
,,
Qian Weigang²,
Teng Jiaxun^{3
,
,},
Sun Xiaofeng^{3
,
,}

1.
Qinhuangdao Vocational and Technical College, Qinhuangdao 066100, China
2.
Qinhuangdao Yanqin Nano Technology Co., Ltd, Qinhuangdao 066010, China
3.
Key Laboratory of Power Electronics for Energy Conservation and Motor Drive of Hebei Province, Yanshan University, Qinhuangdao 066004, China

Received Date: 2023-09-18
Accepted Date: 2023-10-18
Rev Recd Date: 2023-10-18

Available Online: 2023-10-26

Publish Date: 2024-01-12

Abstract

Abstract

Modular multilevel converter (MMC) has become an effective solution for new all-solid-state special high-voltage power supply, and its lightweight design to save equipment space cost has become a research hotspot. The primary factor limiting power density in MMC is the large size capacitance of submodule (SM), and to reduce the demand for the capacitance of the sub-module in modular multilevel converter, and increase system power density, an improved MMC(I-MMC) topology is proposed. Using isolated switched capacitor converters, a pair of SMs of the upper and lower arms are interconnected through a high frequency link. In the research, synchronous control was adopted on both sides of the high-frequency chain connecting the pair of SMs in the phase unit to make the SM capacitors present the characteristics of switched capacitors, realize free transfer of fluctuating power between the capacitors, and eliminate the fluctuation components of the oppostite phased fundamental frequency and triple frequency. Combining MMC operation modulation ratio and power factor, we analyzed the value of the SM capacitor after the fundamental frequency and triple frequency fluctuation components had been eliminated, and completed the modular design. This solution can reduce the sub-module capacitance to 1/4 of the conventional MMC's capacitance. Simulation and experimental results verify the correctness and the validity of the proposed topology scheme.
- modular multilevel converter,
- fluctuation suppression,
- high-frequency link interconnection,
- switched-capacitor

FullText(HTML)

References(15)

References

[1]	姜松, 邱力文, 饶俊峰, 等. 新型全固态高压多电平波形发生器的研制[J]. 强激光与粒子束, 2019, 31:115003 doi: 10.11884/HPLPB201931.190124 Jiang Song, Qiu Liwen, Rao Junfeng, et al. Development of a new all-solid-state high voltage multilevel waveform generator[J]. High Power Laser and Particle Beams, 2019, 31: 115003 doi: 10.11884/HPLPB201931.190124
[2]	汤广福, 罗湘, 魏晓光. 多端直流输电与直流电网技术[J]. 中国电机工程学报, 2013, 33(10):8-17 Tang Guangfu, Luo Xiang, Wei Xiaoguang. Multi-terminal HVDC and DC-grid technology[J]. Proceedings of the CSEE, 2013, 33(10): 8-17
[3]	徐旭哲, 周杨, 孙鹞鸿. 磁隔离触发式10 kV级联型脉冲电源研制[J]. 强激光与粒子束, 2016, 28:075001 doi: 10.11884/HPLPB201628.075001 Xu Xuzhe, Zhou Yang, Sun Yaohong. Development of 10 kV cascaded pulse power supply based on magnetic isolation trigger[J]. High Power Laser and Particle Beams, 2016, 28: 075001 doi: 10.11884/HPLPB201628.075001
[4]	滕甲训, 赵巍, 潘禹卓, 等. 基于开关电容结构的MMC子模块波动功率耦合方案及其参数约束[J]. 中国电机工程学报, 2021, 41(21):7449-7463 Teng Jiaxun, Zhao Wei, Pan Yuzhuo, et al. A fluctuating power coupling method for submodules of MMC based on switched-capacitors and its parameters constraint[J]. Proceedings of the CSEE, 2021, 41(21): 7449-7463
[5]	滕甲训, 潘禹卓, 卜泽敏, 等. 基于谐振式推挽结构的三端口MMC-SST波动功率耦合方案研究[J]. 中国电机工程学报, 2022, 42(6):2308-2320 Teng Jiaxun, Pan Yuzhuo, Bu Zemin, et al. Research on fluctuating power coupling scheme of three-port MMC-SST based on resonant push-pull structure[J]. Proceedings of the CSEE, 2022, 42(6): 2308-2320
[6]	Debnath S, Qin Jiangchao, Saeedifard M. Control and stability analysis of modular multilevel converter under low-frequency operation[J]. IEEE Transactions on Industrial Electronics, 2015, 62(9): 5329-5339. doi: 10.1109/TIE.2015.2414908
[7]	董鹏, 蔡旭, 吕敬. 大幅减小子模块电容容值的MMC优化方法[J]. 中国电机工程学报, 2018, 38(18):5369-5380 Dong Peng, Cai Xu, Lü Jing. Optimized method of MMC for greatly reducing the capacitance of the submodules[J]. Proceedings of the CSEE, 2018, 38(18): 5369-5380
[8]	李笑倩, 刘文华, 孙树敏, 等. 利用环流的MMC电容电压波动抑制方法[J]. 电力电子技术, 2018, 52(11):30-32,74 Li Xiaoqian, Liu Wenhua, Sun Shumin, et al. Capacitor voltage ripple suppression method of MMC using circulating current[J]. Power Electronics, 2018, 52(11): 30-32,74
[9]	黄守道, 彭也伦, 廖武. 模块化多电平型变流器电容电压波动及其抑制策略研究[J]. 电工技术学报, 2015, 30(7):62-71 Huang Shoudao, Peng Yelun, Liao Wu. Study of capacitor voltage fluctuation and its suppression for modular multilevel converter[J]. Transactions of China Electrotechnical Society, 2015, 30(7): 62-71
[10]	Du Sixing, Wu Bin, Zargari N R, et al. A flying-capacitor modular multilevel converter for medium-voltage motor drive[J]. IEEE Transactions on Power Electronics, 2017, 32(3): 2081-2089. doi: 10.1109/TPEL.2016.2565510
[11]	Li Binbin, Zhou Shaoze, Xu Dianguo, et al. A hybrid modular multilevel converter for medium-voltage variable-speed motor drives[J]. IEEE Transactions on Power Electronics, 2017, 32(6): 4619-4630. doi: 10.1109/TPEL.2016.2598286
[12]	李国庆, 王威儒, 辛业春, 等. 模块化多电平换流器子模块分组排序调制策略[J]. 高电压技术, 2018, 44(7):2107-2114 Li Guoqing, Wang Weiru, Xin Yechun, et al. Sub-module grouping modulation strategy of modular multilevel converter[J]. High Voltage Engineering, 2018, 44(7): 2107-2114
[13]	Tu Chunming, Xiao Fan, Lan Zheng, et al. Analysis and control of a novel modular-based energy router for DC microgrid cluster[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2019, 7(1): 331-342. doi: 10.1109/JESTPE.2018.2878004
[14]	班明飞, 申科, 王建赜, 等. 基于准比例谐振控制的MMC新型环流抑制器[J]. 电力系统自动化, 2014, 38(11):85-89,129 Ban Mingfei, Shen Ke, Wang Jianze, et al. A novel circulating current suppressor for modular multilevel converters based on quasi-proportional-resonant control[J]. Automation of Electric Power Systems, 2014, 38(11): 85-89,129
[15]	徐政, 屠卿瑞, 管敏渊, 等. 柔性直流输电系统[M]. 北京: 机械工业出版社, 2012 Xu Zheng, Tu Qingrui, Guan Minyuan, et al. Flexible DC transmission system[M]. Beijing: China Machine Press, 2012