Turn off MathJax
Article Contents
Sun Weixiang, Wang Xinzheng, Shi Leilei, et al. Parameter optimization of dual active bridge converter under extended phase shift modulation[J]. High Power Laser and Particle Beams. doi: 10.11884/HPLPB202537.250043
Citation: Sun Weixiang, Wang Xinzheng, Shi Leilei, et al. Parameter optimization of dual active bridge converter under extended phase shift modulation[J]. High Power Laser and Particle Beams. doi: 10.11884/HPLPB202537.250043

Parameter optimization of dual active bridge converter under extended phase shift modulation

doi: 10.11884/HPLPB202537.250043
  • Received Date: 2025-03-10
  • Accepted Date: 2025-06-27
  • Rev Recd Date: 2025-06-30
  • Available Online: 2025-07-07
  • With the advancement of active phased array radar, the requirement for transmit-receive (TR) power supplies in phased array radar has been escalating continuously. TR power supplies featuring wide input voltage range, high frequency, and high efficiency have emerged as the prevailing research orientation nowadays. Dual active bridge (DAB) converters can realize wide input voltage range and offer diversified control methods, thereby holding extensive application prospects in the domain of TR power supplies. Nevertheless, the system parameters such as inductance and switching frequency of DAB converters exert a considerable influence on the transmission power of TR power supplies and the on-state current of power MOSFETs. Based on the extend-phase-shift (EPS) modulation approach in DAB converters, this paper deduces the expressions of power transmission characteristics and inductor current magnitude, and proposes a parameter optimization design method for DAB circuits under EPS modulation. With the maximum transmission power considering overload requirements, the derating design of the maximum on-state current of MOS devices, and the minimum output voltage ripple frequency as restrictive indicators, the reliable operation area (ROA) is planned based on the parameter limitations, providing a reference basis for designing the corresponding inductance value, switching frequency, and optimizing DAB parameters. Finally, through the corresponding MATLAB simulation analysis of a two-output DAB converter, the simulation results indicate that the output voltage ripple, the on-state current of MOSFETs, and the output power conform to the expected demand indicators, validating the accuracy of the above theoretical derivation.
  • loading
  • [1]
    包敏杰, 俞小莉, 黄瑞, 等. 大功率燃料电池建模与电压一致性分析[J]. 储能科学与技术, 2024, 13(3): 952-961

    Bao Minjie, Yu Xiaoli, Huang Rui, et al. High-power fuel cell modeling and voltage uniformity analysis[J]. Energy Storage Science and Technology, 2024, 13(3): 952-962
    [2]
    张才清, 孙轶, 张磊. 高功率密度雷达脉冲负载电源[J]. 现代雷达, 2021, 43(3):94-98

    Zhang Caiqing, Sun Yi, Zhang Lei. High power density pulse power source design[J]. Modern Radar, 2021, 43(3): 94-98
    [3]
    王正之, 白璐, 黄晓燕. 相控阵雷达阵面电源储能电容的特性研究[J]. 数字技术与应用, 2020, 38(5):40-41

    Wang Zhengzhi, Bai Lu, Huang Xiaoyan. Research on the characteristics of energy-storage capacitor of the power supply for phased array radar[J]. Digital Technology and Application, 2020, 38(5): 40-41
    [4]
    张宝敏, 曾钢. 新型固定式相控阵雷达供电系统研究[J]. 中文科技期刊数据库(全文版)工程技术, 2023(6):58-61

    Zhang Baomin, Zeng Gang. Research on new fixed phased array radar power supply system[J]. Chinese Science and Technology Periodicals Database (Full-text Edition) Engineering Technology, 2023(6): 58-61
    [5]
    蒋华, 陈善华. 一种雷达阵面T/R供电模块的研究与实践[J]. 现代雷达, 2012, 34(7):64-67 doi: 10.3969/j.issn.1004-7859.2012.07.016

    Jiang Hua, Chen Shanhua. Research and practice of a power module for radar array T/R[J]. Modern Radar, 2012, 34(7): 64-67 doi: 10.3969/j.issn.1004-7859.2012.07.016
    [6]
    操建生, 于新红, 许立斌, 等. 双有源全桥变换器无模型预测控制策略[J]. 微特电机, 2024, 52(2):64-69 doi: 10.3969/j.issn.1004-7018.2024.02.012

    Cao Jiansheng, Yu Xinhong, Xu Libin, et al. Model-free predictive control strategy for dual active full-bridge converters[J]. Small & Special Electrical Machines, 2024, 52(2): 64-69 doi: 10.3969/j.issn.1004-7018.2024.02.012
    [7]
    杨向真, 王锦秀, 孔令浩, 等. 电压不匹配运行条件下双有源桥变换器的效率优化方法[J]. 电工技术学报, 2022, 37(24):6239-6251

    Yang Xiangzhen, Wang Jinxiu, Kong Linghao, et al. Efficiency optimization method of DAB converters under wide-voltage operating conditions[J]. Transactions of China Electrotechnical Society, 2022, 37(24): 6239-6251
    [8]
    刘春喜, 徐金荣, 刘文强, 等. 扩展移相控制的DAB变换器双目标优化策略[J]. 电子测量与仪器学报, 2024, 38(10):180-190

    Liu Chunxi, Xu Jinrong, Liu Wenqiang, et al. Dual-objective optimization strategy for DAB converter with extended phase shift control[J]. Journal of Electronic Measurement and Instrumentation, 2024, 38(10): 180-190
    [9]
    王祺, 张泽轲, 刘彬, 等. 双重移相控制下双有源桥变换器最小回流功率全局优化控制[J]. 电网技术, 2024, 48(9):3921-3930

    Wang Qi, Zhang Zeke, Liu Bin, et al. Global optimization control of minimum backflow power for dual-active-bridge converters under dual-phase-shift control[J]. Power System Technology, 2024, 48(9): 3921-3930
    [10]
    曾进辉, 饶尧, 兰征, 等. 三重移相控制的DAB变换器多目标统一优化控制策略[J]. 电源学报, 2024, 22(5):74-85,132

    Zeng Jinhui, Rao Yao, Lan Zheng, et al. Multi-objective unified optimal control strategy for DAB converter with triple-phase-shift control[J]. Journal of Power Supply, 2024, 22(5): 74-85,132
    [11]
    Huang Jun, Wang Yue, Li Zhuoqiang, et al. Unified triple-phase-shift control to minimize current stress and achieve full soft-switching of isolated bidirectional DC–DC converter[J]. IEEE Transactions on Industrial Electronics, 2016, 63(7): 4169-4179. doi: 10.1109/TIE.2016.2543182
    [12]
    黄匀飞, 钟启濠, 欧阳有鹏, 等. 双有源桥变换器拓扑结构与控制策略研究综述[J]. 电源学报, 2024, 22(4):53-65

    Huang Yunfei, Zhong Qihao, Ouyang Youpeng, et al. Overview of topologies and control strategies for dual-active-bridge converters[J]. Journal of Power Supply, 2024, 22(4): 53-65
    [13]
    赵彪, 宋强. 双主动全桥DC-DC变换器的理论和应用技术[M]. 北京: 科学出版社, 2017

    Zhao Biao, Song Qiang. Theory and application technology of dual active full-bridge DC-DC converter[M]. Beijing: Science Press, 2017
    [14]
    孙志峰. 双有源全桥DC-DC变换器优化调制与并联均流控制[D]. 株洲: 湖南工业大学, 2019

    Sun Zhifeng. Optimal modulation and parallel current sharing control of dual active full-bridge DC-DC converter[D]. Zhuzhou: Hunan University of Technology, 2019
    [15]
    童安平, 杭丽君, 李国杰. 三重移相控制下DAB变换器全局优化控制策略及分析[J]. 中国电机工程学报, 2017, 37(20):6037-6049

    Tong Anping, Hang Lijun, Li Guojie. Global optimized control strategy of dual active bridge converter controlled by triple-phase-shift modulation scheme and its analysis[J]. Proceedings of the CSEE, 2017, 37(20): 6037-6049
    [16]
    邵持, 童安平, 钱语安, 等. 三重移相调制下DAB变换器全功率范围统一ZVS控制策略[J]. 中国电机工程学报, 2019, 39(19):5644-5655

    Shao Chi, Tong Anping, Qian Yu'an, et al. Triple-phase-shift based unified ZVS modulation strategy of dual active bridge converter for full operation range[J]. Proceedings of the CSEE, 2019, 39(19): 5644-5655
    [17]
    GJB/Z 35-93, 元器件降额准则[S]

    GJB/Z 35-93, Derating criteria for electrical, electronic and electromechanical parts[S]
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索

    Figures(13)

    Article views (28) PDF downloads(1) Cited by()
    Proportional views
    Related

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return